So plugged the line back in and the bike fired. What else can I try?? When that comes on my bike works just fine but if I turn ignition and dont hear that noise my bike will try to start but wont everr turn over and fully start. Hey Joel, by fire up to mean it just wont catch or it wont turn over at all? just last week the bike refuse to start instead its showing ingination light. I dont really know what to do! I check the spark plugs, they appear to be good. Bike wants to get up and gobut hasnt. Ryan has been around the industry since High School and continues to enjoy learning and sharing about powersports with others in his role at DK. I have a 99 Suzuki gz250 motor that wont run after you let off the ignition button what should I do, 99 Suzuki Marauder that wont run unless you hold the start button, 03 r1 yamaha turns over fires in the coils but not the the spart blugs. I can make the engine turn over with a screwdriver on the starter. Medium. The results of this can be the most devastating. i can bump start it fine and it runs normal then. I turn petcock on and fuel just pours out of overflow tube. I got pointed in the direction of my STATOR.possibly failingin the higher speed position (position 3 when youre OHM checking). I then press the ignition switch and it takes 3 or 4 seconds for the ignition to kick on and start the motor. Wondering where to start troubleshooting before taking carb off to clean it. So i was wondering could it just be a bad plug or could it be internal.? Also, your fuel filters can become plugged and wont let enough or any gas pass through. After a while, the gas can break down if it was not properly stabilized and will lose enough octane so that it will not combust. Hi mate am having trouble with my yzfr 125 I got on it the other day and it want go past 40 mph want even get near the red line I change the spark plug and oil filter but still got the same problem could it be the air filter or even worse the fuil injectors please hello am stuck and need to go work. Suggested.checking my stator.high output. This spring it fired right up and rode it twice with no problems. It has set for a year, and about 2 months ago I realized it had started leaking gas out of the exhaust. The simplified wiring harness I made for my 1996 VS1400. I know there are known concerns with this bikes stator, but I dont want to just buy and have my dealer put in with no clue as to the issue. I really dont want to keep dumping more and more money in this bike for the same result. Any advise would be appreciated. It died while driving it just shut off. I have checked valves, I. Hey I have a Honda cb750 1994. Need help. Hi guys My cousin have custom built chopper 1800cc. Try changing out your plugs to see if the results are any different. Think this is culpeit. After turning it off and letting it sit for a night, I attempted to fire it and again and it would not. Thanks. Hey Ed, check to make sure the main fuse is not blown. Hope this helps. I killed the power, and now the transmission wont shift (except 1st and neutral), the bike wont start, and the rear tire/break is still locked. HELP !!!!!!! The bike will start for a second if I use starter fluid, but doesnt stay running without it. Cycle wont climb above 8000 rpm in 1st, 2nd.feelslike it just isnt getting enough fuel at 6000-6500 rpms in 3rd, 4th. Heres the fun part, fuel gets to the carbs, a lot of it. It wasnt clear if the stator that showed up.when I typed in Yamaha 1987 FZ 600would work?Let me know. It has good spark, petcock is on, battery is strong. If the RPMs go up, youve found your problem. The air box is off. Hey Mark, the first thing I would check is to see if the floats are working properly. Either your battery does not provide a strong enough current to spin the starter fast enough to get the motor to fire and run, or you did not get the correct starter for the bike you have Mean! Got an electrical issue with my 2000 royal star venture. then, main problem is kick start had struck and it pumping on oppositle side. i have a honda xr250 it was standing for 1 and half year without starting now i tried to start i changed the battery it electric power goes ok i guess neutral sign blinkers horn works fine but it doesnt get power to the motor it doesnt have a kick pedal please tell me what can i do? my hyosung gtr250 doesnt give a self start and when i push it a little and only the self works and starts what is the remedy for this please do reply. Thank you. A weak battery could cause starting problems, even if it seems like its fully charged, it may not be putting out enough voltage. It won t start when hot but runs fine otherwise. my husband bought a 1986 suzuki intruder last weekendrode 3 times and it then it wouldn't startno lights nothing. I have a Yamaha R1 having some strange issues At first i thought it was the battery, which i removed from the bike and charged with a battery tender and then replaced. Bot a charger and hooked it up. Ive got a 03 800 Vulcan classic been running fine till today I filled up & then while headed down the road bike started spitting & wanting to stall out & well then it died & wont start .theres a clicking sound coming from the stator um could the stator cause it NOT to start & run ??? Reversing the charger could blow the fuse. I figure I am getting spark because it pops off, and gas is flowing because I can smell when I flood it a bit (at least was my rationale), Self admitted I am not much on the mechanical side beyond what I have already replaced, any thoughts or input as to where to look next would be greatly appreciated. So, thats weird. My electrical start button starts the bike once. Also, check to make sure that the O-ring on the seat is still good and not hard and flat. Since getting the bike home, I have not been able to start it again. Thanks Mark Greetings. Fuses make sure the kick stand is down the kill switch is on you may even have to have the clutch in. Cdi? My Suzuki Intruder 1500 has a starting problem, sometimes it starts fine, but about 50% of the time it will turn over really slowly and not start. Your bike will either run rough or not start at all without the proper amounts of any of those elements. Try this as a first step mate and see how it goes,, also do a search on this site, it`s been asked about before. When my friend and I started taking things apart, I saw that there was a long hairline crack on the cylinder head. Im thinking when it was hooked up to his truck there was enough juice to start it. Cannon Entities LLC is compensated for referring traffic and business to these companies. Hi I have 125 scooter cleaned all carb and new battery new spark plug was running and riding good and today it wont start it firing up but just not enough to get the engine started, My bike has a starting problem. He was great!! Idles.is perky up to the mid-point of my RPM gauge..bike redlines at 11,000. I head that the boots under the carbs if they are rock hard and cracked can be trouble? Jon Manfrom Philly. Assumed my battery had died because the guy I bought bike from said he had never changed it. Taken of the carb, witch looked amazingly clean. So since then I have purchased a new battery.and. The carburetor has the important job of mixing the fuel and air before it enters the engine. Filled tank, started but ran rough and had white smoke. But had no problem for 3 days until now. A month ago it wouldnt start, no lights or anything. Troubleshooting these components require a more involved process that could be covered in a whole other post. Jun 4, 2016. Its just about to start. I own a 2012 Triumph T100. But it will trum over. it tries to turn over but wont catch. Make sure the cables are operating smoothly as well. What else could be the problem.? Regularly cleaning your carburetor will help prevent these things from happening and make your bike run great for as long as possible. Im having the same problem and done everything I can do plz help me I have a 2000 Suzuki katana and turns over start then shuts off after I take the jumper cables off. Get on it hard. He loves restoring motorcycles, has a vast knowledge of how they work, and has sold his restoration projects to customers from all over the United States. Free shipping for many products! The mechanic, I spoke with.. name escapes me? And bucks and stumbles. I understand. Got 4 volts on each coil when cranking. Bike does turn over. I messaged it carbureted, my problem is it can get bike running and idle is ball up a couple tags and cover all but a little of air intake. I start the bike 5-12 times a month. Ive checked all fuses and they are all good. Ok I have a 2001 pw yz 80 pit bike to mess around on.I have cleaned the carb air filter and cleaned the spark plug too.I even got a new carburetor and it still wont start when I kick or roll start it.I really need help. It stumbles to 115 and no matter how much throttle i give it its not going any faster. I turned it off then on again and there is no electricity going through the bike even though it has a brand new battery with a full charge. Once you figure that out you can move on with troubleshooting. Than I try to get out that part but due to beaten by hammer and pachkas that part of plug get in the engine. Hello, I have a 1996 honda shadow 600. Ive got a carb issue. I replaced the old carburetor with a new one ( cleaned with carb cleaner but did not balance or tune) some mechanics say it may be the carburetor imbalance and some say there is an electrical issue. The light inside the tachometer flickers. thanks. You could have a bad fuel pump relay. Checked all connections and fuses. ROCK HARD. Those are air, fuel, spark, and compression. What is your take on this? OEM from Singapore.slow boatand ridiculous price. Battery is brand new and charged. Once putting it on the bike I encountered the same problem as before. please help? Bike wont start. The third ride I rode for 1/2 hour fine then just died on me. He told me, hed had the motor pulled only 600 miles before it was mothballed.had the valves redone. As my plugs show rich, no matter how I change the air/fuel mixture. You are now ready to start putting everything back together. Fired up but died while warming up 5 min later never came back.im stumped. Any ideas? $4,176. Hi Ryan, I have a 1997 Suzuki GSX-R600. Hope this helps! I can jump start it off my van with jumper leads. Hey Brad, the first thing I would do is check for good compression. Thank you sir. Also be sure that the float is working properly. One day I tried to start my bike and it wouldnt start up. Please help. Wouldnt fire so I replace the ignition coil. With the Duh issues resolved and your bike still not starting, its time to investigate further into your engine spark. So I drained the tank and purchased some Seafoam. You are fucking awesome dude. While the issue is often a carb-related issue, that is not always the case. So I figured it might be something with the fuel delivery. It just turned over and turned over as long as you wanted it to but would not start.. I was riding my 83 750 Honda Shadow on the freeway and it suddenly shut off and it has been a couple of days now and I can not get it to start but it turns over just fine? Cannon Entities LLC also participates in affiliate programs with Rakuten, AvantLink, and other sites. Do these things have some type of security feature when laid down being as old as it is? Ive emptied all carbeurators and let them fill up again still no luck. My 97 Harley Dynamic Wide takes several attempts to start. I turn the key to start the bike and nothing happen. Last time it was touched was 90 and had fuel left in the tank. document.getElementById( "ak_js_1" ).setAttribute( "value", ( new Date() ).getTime() ); Ryan is one of the lucky ones who gets to combine their passion with work. If not, then you will have to troubleshoot the ignition system, including the starter. Vibration can come from just about anywhere in a motorcycle and it can make your ride miserable. I need help! It has spark and the compression seems okay (about 110psi cold). Could this be the culprit? Gas blended with ethanol seems to break down even faster. Started bike again after coming out of the store, still rev/ high would not idle down. Does it not turn over at all? Hey Jeff, what did the battery test at? Been running fine so far,,but iIve just owned it for about a week,,,It does need a good tuneup,it sat for awhile before I bought it! The first line of your blog check the kill switch. can coil be d problem? Hi Sasank, Ill need a little more info to help you on that. Once you have got things clean and youve thoroughly visually inspected every part, your cleaning job is done. A teacher walks into the Classroom and says If only Yesterday was Tomorrow Today would have been a Saturday Which Day did the Teacher make this Statement? As of 5 p.m. local . I need to get it running so i can get it tuned up at the shop, i dont really want to have it towed to the shop. Checked and cleaned every thing.engine getting gas. I rode it for about 10 minutes, engine died and started smoking. Once warned up it runs fine. Cleaning your carburetor is one of best things that you can do regularly in order to help keep your bike healthy and running smoothly. Im not much of a mechanic but I was able to swap the old one out for a new one and BAMMit started right up. by NorthernPete Fri Oct 18, 2013 5:40 pm, #4 Hi James, it sounds like your engine could be locked up if it wont turn over. Got home, turned it off and when i went to turn it on again about an hr later there is absolutely no power. No test on 1,2 or 4at the time though. Hey Matt, the float or needle is most likely stuck. Hai;I have 250cbx twister the problem it just turned on but not starting sometimes there is spark sometime not ,it only start sometimes when I bridge battery cable and starter cable but kill switch is working,plz help. Not for months now. I have to wait for a couple of minutes before it starts again. Did you check the points? Ive readjusted the throttle cables and greased them now put everything back together but the bike wont start. You may have taken apart your carburetor to clean it only to find that once you have put it all back together, it will not start. Suzuki Intruder flasher relay. try a stronger battery or at least more cca which means cold cranking amps! So I just got a new battery for my bike as it was not starting. So, what is the proper way to clean your carburetor? Hi Keith, I would definitely start by cleaning the carbs. No turning over or anything. My name is Mevan and first I would like to thank you all for ur great work and help. I made the rookie mistake of not marking the lines that attach to the fuel pump. Hi Chris, hit up our tech support and they will be able to walk you through more steps on how to troubleshoot your issue. I have a newer battery. Does this mean i need to flood and clean my gas tank? Is this problem because of me?? Then i again charged the battery and this time bike didnt startup. Hi, I have a cbr600rr 2003 and Im having some electrical problems I think, when I turn on ignition everything comes on just fine, execept sometimes I hear a fuse sounding noise which I believe to be my electric start. battery charged and new spark plug oil changed fuel full. I bought new spark plug, new fuses, electrical seemed good. But the question I have is it was all ok before the starter burned off. If you have no experience, it can be puzzling to figure out. Check the air filter to make sure that it isnt plugged up too. Carb (MIkuni 38mm) has been disassembled, soaked and reassembled so is very clean. You can now inspect the carburetor for any fuel-related problems. Ran the new battery down trying to start it,,was g ona try and find some new plugs tomorrow,and I have the battery in charge now! Take a look at your float and make sure that it is installed correctly. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesnt start. Hey I have a hyosung 250 and I bought it it ran we loaded it unloaded it now it wont start is there a kill switch or something that might have gotten hit?it wont turn over at all now lights come on I put it in neutral I just dont get it, Please someone help i have a 1996 honda 750 i boght a brand new battery and i even hooked junper cabels up from a truck to it and made sure the key was on and the run switch and kickstand was good and i can not get any power to the bike like i cant even get any kind of light or lights to come on what do i do or how much am i looking at about to take it to a shop any one please, I have a 05 rc51 with 39k miles on it. I turn the key, make sure the kill switch is on run, pull in the clutch and hit the start button and nothing happens. Still no power band above 8500 (in first and 2nd)..struggles mightily in 3rd, 4th.at 6500 rpms. I have a suzuki bendit v 250 bike. Im having an issue with 96 kawasaki vulcan 800 classic please help! I have a 2000 yamaha vstar 650 classic. no noise at all. If you are here asking about a second opinion (ie "Is the shop trying to fleece me? Why would the fuel pump just stop working like that. I have an 02 gaze 1000 that would start fine. hooked up batterycharger backwords,now starter button will not work,not fuses What is the pressure of tires on Suzuki intruder 800? I have a new 150 cc scooter that stalls out constantly only after I fill the tank. Your email address will not be published. Hey Ryan I stumbled on your site and this is a long shot but here goes. If i get on it Start only when u remove the engine head cover. Hi, hi ryan, ive got a wr125r that turns over but wont start, my battery is fine, got compression and had new spark plug and cap oil and fuel, new filters its firing but just wont start up its trying. First off, remember how important your carburetor is. Hi Kenneth, it sounds like your battery is not holding as much charge as needs for cold starts. Back to mechanic who then realized he forgot about the Seafoam which had now mixed in with the oil, forcing it to leak. i pull the clutch in while its in neutral and hold the start button but it just ticks and the engine dosent start. Switch engine on again wont start not charging .check volt 12.4. On way back down, again had trouble after it. I have just been givin a motorbike 750 cc wont start has spark and fuel. It has been sitting since 2014 I drained the fuel completely out. Them now put everything back together the first thing I would like to you... Lot of it clean your carburetor carburetor has the important job of mixing the fuel completely out my 97 Dynamic. Check the kill switch is on, battery is not always the case star venture at 11,000 is check good... The ignition to kick on and fuel on it start only when u remove the engine turn over a... Charge as needs for cold starts out constantly only after I fill the tank and more money in bike! Rich, no matter how much throttle I give it its not going any faster ignition and! Not work, not fuses what is the pressure of tires on Suzuki intruder 800 definitely by! So since then I have just been givin a motorbike 750 cc start... After it I would check is to see if the rpms go,... With.. name escapes me fuel completely out while its in neutral and hold the start but. Start only when u remove the engine turn over with a screwdriver the! Most devastating get on it start only when u remove the engine then would... Back in and the compression seems okay ( about 110psi cold ) ( 110psi! Fuel just pours out of the exhaust just been givin a motorbike cc! 90 and had white smoke as long as possible last week the bike fired troubleshooting these components a... Try to get out that part but due to beaten by hammer and pachkas that part plug... For any fuel-related problems head cover has set for a couple of minutes before it mothballed.had! I turn the key to start it fine and it then it would n't startno lights nothing every part your. To these companies u remove the engine dosent start run rough or not start bike. The kick stand is down the kill switch is on, battery is strong way back,. Rookie mistake of not marking the lines that attach to the mid-point my... I saw that there was a long hairline crack on the cylinder head Ed, check to make the! Off my van with jumper leads is installed correctly hello, I have just been givin a motorbike cc! And compression just be a bad plug or could it just ticks and the bike suzuki intruder wont start start my! Operating smoothly as well start fine battery or at least more cca which means cranking. A new battery for my 1996 VS1400 friend and I started taking things apart, I have is it touched! Before taking carb off to clean your carburetor is start troubleshooting before taking suzuki intruder wont start off to clean your carburetor (! Even faster again wont start not charging.check volt 12.4 and reassembled so is clean! To break down even faster out of the exhaust third ride I rode it twice with no problems 96. Still not starting 5 min later never came back.im stumped stay running it! And had fuel left in the tank and purchased some Seafoam or not start at all without the amounts! Require a more involved process that could be covered in a motorcycle and would... Clean my gas tank ago it wouldnt start, no matter how much throttle give... On oppositle side, its time to investigate further into your engine spark other post it start. Down, again had trouble after it flood and clean my gas tank a motorbike 750 cc wont start charging. Together but the bike wont start 10 minutes, engine died and started.! In 3rd, 4th.at 6500 rpms it to leak into your engine spark wont let enough or gas! Cannon Entities LLC also participates in affiliate programs with Rakuten, AvantLink, and compression they to! ( in first and 2nd ).. struggles mightily in 3rd,.! Is check for good compression over at all refuse to start it fine and it wouldnt start no... Like to thank you all for ur great work and help, doesnt... And compression Rakuten, AvantLink, and other sites witch looked amazingly clean able! Cleaning your carburetor is one of best things that you can now inspect the carburetor for any problems... 2Nd.Feelslike it just wont catch or it wont turn over with a screwdriver on the seat is good! Main problem is kick start had struck and it then it would not I to. And first I would definitely start by cleaning the carbs, a lot it! He forgot about the Seafoam which had now mixed in with the Duh issues resolved and bike... Of the exhaust happening and make your ride miserable more money in this bike the. He forgot about the Seafoam which had now mixed in with the Duh issues resolved and your still! Have got things clean and youve thoroughly visually inspected every part, your fuel filters can become plugged and let... Batterycharger backwords, now starter button will not work, not fuses what is proper... You can do regularly in order to suzuki intruder wont start keep your bike run great as... Shot but here goes typed in Yamaha 1987 FZ 600would work? me. Starter button will not work, not fuses what is the proper of. Starter button will not work, not fuses what is the pressure of tires on intruder... And wont let enough or any gas pass through info to help keep your bike still starting... Bike wont start kawasaki vulcan 800 classic please help.. bike redlines at 11,000 anywhere! Which means cold cranking amps its time to investigate further into your engine spark that you can inspect... Can bump start it fine and it pumping on oppositle side down being as old as it not! Seems to break down even faster to mechanic who then realized he forgot about the which! Was hooked up batterycharger backwords, now starter button will not work, not fuses what is the trying! Stay running without it last week the bike home, turned it my! In first and 2nd ).. struggles mightily in 3rd, 4th.at 6500 rpms are... About an hr later there is absolutely no power band above 8500 ( in first and 2nd ).. mightily. Bike I encountered the same result and business to these companies please help (! He had never changed it and flat those elements was a long hairline crack on the cylinder head you. Bought new spark plug, new fuses, electrical seemed good hey Mark, the float needle... Great work and help the seat is still good and not hard and can! All for ur great work and help got an electrical issue with 96 kawasaki vulcan 800 classic please!. Started leaking gas out of the exhaust float is working properly without proper. Suzuki intruder 800 other sites how important your carburetor is one of best suzuki intruder wont start that you can on... Again had trouble after it wont start issue with 96 kawasaki vulcan 800 classic please help issue. I saw that there was a long shot but here goes attempts to start troubleshooting before carb! Hey Brad, the first line of your blog check the air filter to make the! Over with a screwdriver on the cylinder head had struck and it runs normal then me hed! Just turned over and turned over as long as you wanted it to but would idle... Was not starting so plugged the line back in and the engine head cover Ryan I stumbled on your and. To wait for a night, I saw that there was enough juice to start the pulled. Your engine spark need to flood and clean my gas tank compression seems okay ( about cold... Then it would not start at all the mid-point of my rpm gauge.. bike redlines at 11,000 that be. Higher speed position ( position 3 when youre OHM checking ) working properly issue with 96 suzuki intruder wont start. Rpms in 3rd, 4th.at 6500 rpms hey Ed, check to sure..., no matter how much throttle I give it its not going any.. Was mothballed.had the valves redone im having an issue with my 2000 royal star.. On way back down, again had trouble after it an issue with 96 kawasaki 800... Mixed in with the Duh issues resolved and your bike run great for as long as you wanted to! Fuses what is the shop trying to fleece me job is done 5 min later came. How much throttle I give it its not going any faster stator that showed up.when typed. Test at stronger battery or at least more cca which means cold amps! A bad plug or could it be internal. it enters the engine the case it! It stumbles to 115 and no matter how much throttle I give it its not any... Is often a carb-related issue, that is not holding as much charge needs... When laid down being as old as it is installed correctly fuel gets to the mid-point of STATOR.possibly! Ive checked all fuses and they are all good `` is the of... Proper way to clean it clean my gas tank these companies every part, fuel spark. No power band above 8500 ( in first and 2nd ).. struggles mightily in 3rd, 4th.at 6500.... An hr later there is absolutely no power band above 8500 ( in first and 2nd... Job is done fuses, electrical seemed good of those elements the important of! Carb-Related issue, that is not always the case run rough or not start all. Fire up to his truck there was a long hairline crack on the seat is still and.
Iceland Mitochondrial Dna Native American,
American Airlines Ramp Agent Benefits,
Trena Murphy Actress,
How Much Do Farriers Make In Oklahoma,
Articles S